Cheesy Beef-Stuffed Puff Pastry Rolls

Ingredients

For the Beef Filling

• 1 lb (450 g) Lean Ground Beef (85/15 or 90/10): Provides hearty flavor without rendering excess liquid that softens the pastry.
• 1 medium Yellow Onion: Finely diced.
• 3 cloves Garlic: Minced.
• 1 tbsp Olive Oil: For sautéing.
• 1 tbsp Tomato Paste: Adds concentrated savory sweetness and binds the meat mixture.
• 1 tbsp Worcestershire Sauce: Enhances beefiness.
• 1 tsp Smoked Paprika: Adds depth and subtle smokiness.
• 1 tsp Dried Italian Oregano or Thyme: For herbal balance.
• 1 tsp Kosher Salt: Adjust to taste.
• ½ tsp Freshly Cracked Black Pepper: Coarse grind.
• 2 tbsp Fresh Flat-Leaf Parsley: Finely chopped.

For Assembly & Crust

• 2 sheets Ready-Rolled Puff Pastry (approx. 14 oz / 400 g total): Thawed in the refrigerator overnight.
• 1 cup Sharp Cheddar Cheese: Freshly shredded.
• 1 cup Whole-Milk Low-Moisture Mozzarella: Freshly shredded.
• 1 large Egg: Beaten with 1 tablespoon water (egg wash).
• 1 tbsp Sesame Seeds or Everything Bagel Seasoning (Optional): For topping.

Instructions

Step 1: Cook the Beef Filling

1. Heat Intensity: Medium-high (Stovetop)
2. Time: 8 to 10 minutes
3. Heat olive oil in a large heavy skillet over medium-high heat until shimmering.
4. Add the finely diced onion. Sauté for 3 to 4 minutes until translucent and lightly softened.
5. Add the ground beef, breaking it apart with a wooden spoon into very fine crumbles. Cook for 5 to 6 minutes until browned and no pink remains.
6. Stir in minced garlic, tomato paste, Worcestershire sauce, smoked paprika, dried oregano, kosher salt, and black pepper. Stir continuously for 1 to 2 minutes until fragrant and the tomato paste coats the beef evenly.
7. Remove skillet from heat and fold in chopped parsley.
8. Critical Step: Drain off any accumulated fat thoroughly using a fine-mesh strainer. Transfer the beef filling to a wide, shallow plate and allow it to cool completely to room temperature (about 15 minutes). Never spread warm filling over cold puff pastry , as the butter in the dough will melt prematurely, causing soggy, flat pastry.

Step 2: Prepare the Pastry Base

1. Intensity: Low / Delicate handling
2. Time: 5 minutes
3. Preheat your oven to 400°F (200°C) with convection/fan-forced, or 425°F (220°C) for conventional bake. Line two large baking sheets with unbleached parchment paper.
4. Lightly dust a clean work surface with flour. Gently unfold the chilled puff pastry sheets.
5. Use a rolling pin to smooth out any fold creases, rolling each sheet into an even 10×12-inch rectangle.

Step 3: Layer and Roll

1. Intensity: Moderate / Precision rolling
2. Time: 10 minutes
3. Leaving a ½-inch clean border along the top edge of each sheet, sprinkle half of the shredded mozzarella and cheddar evenly across both pastry rectangles.
4. Distribute the completely cooled beef mixture evenly across the cheese layer, pressing down lightly with the back of a spoon to compact the meat.
5. Top the beef with the remaining cheese blend.
6. Lightly brush the clean top border with a small amount of the egg wash.
7. Starting from the long edge closest to you, roll the pastry upward tightly into a firm log, keeping even pressure throughout so there are no large air gaps inside.
8. Press the top edge firmly along the seam to seal the cylinder. Place the rolled log seam-side down.
9. Repeat with the second pastry sheet.
10. (Optional but Recommended) Transfer both logs onto a plate and chill in the freezer for 10 minutes. Chilling firms the fat, allowing clean, round slices without squishing the roll.

Step 4: Slice and Egg Wash

1. Intensity: Low
2. Time: 5 minutes
3. Using a very sharp chef’s knife or serrated bread knife, slice each roll into 8 to 9 even pinwheels (approximately 1 to 1.25 inches thick). Wipe the knife clean between cuts for tidy edges.
4. Arrange the rolls cut-side up on the prepared baking sheets, leaving at least 1.5 inches of clearance between each roll to allow for expansion.
5. Brush the exposed pastry edges lightly with the egg wash.
6. Sprinkle tops with sesame seeds or bagel seasoning if desired.

Step 5: Bake to Golden Perfection

1. Heat Intensity: High (400°F / 200°C Oven)
2. Time: 20 to 25 minutes
3. Slide baking sheets onto the center racks of the preheated oven.
4. Bake for 20 to 25 minutes, rotating pans halfway through, until the puff pastry is deep golden brown, crisp on the sides, and the cheese is bubbling at the edges.
5. Remove from the oven and let rest on the baking sheet for 5 minutes before transferring to a serving platter. Serve warm with marinara, garlic aioli, or spicy mustard.

Nutrition

Calories: 385 kcal — · Protein: 18 g 36% · Fat: 24 g 31% · Carbohydrates: 23 g 8% Dietary · Saturated Fat: 10 g 50% · Fiber: 1.5 g 5% · Sugar: 1.8 g — · Sodium: 460 mg 20%